Antinuclear

But thorium can’t fuel a reactor by itself: rather, a uranium- or plutonium-fueled reactor can convert thorium-232 into fissionable (and plutonium-like, highly bomb-usable) uranium-233. Thorium’s proliferation [8], waste, safety, and cost problems differ only in detail from uranium’s: e.g., thorium ore makes less mill waste, but highly radioactive U-232 makes fabricating or reprocessing U-233 fuel hard and costly.

Integrated Fast Reactors (IFRs)

The IFR – a pool-type, liquid-sodium-cooled fast-neutron [4] reactor plus an ambitious new nuclear fuel cycle – was abandoned in 1994 [5], and General Electric’s S-PRISM design in ~2003, due to both proliferation concerns and dismal economics.

Federal funding for fast breeder reactors [6] halted in 1983, but in the past few years, enthusiasts got renewed Bush Administration support by portraying IFRs as a solution to proliferation and nuclear waste. It’s neither.

Fast reactors were first offered as a way to make more plutonium to augment and ultimately replace scarce uranium. Now that uranium and enrichment are known to get cheaper while reprocessing, cleanup, and nonproliferation get costlier – destroying the economic rationale – IFRs have been rebranded as a way to destroy the plutonium (and similar transuranic elements) in long-lived radioactive waste.

Two or three redesigned IFRs could in principle fission the plutonium produced by each four LWRs without making more net plutonium. However, most LWRs will have retired before even one commercial-size IFR could be built; LWRs won’t be replaced with more LWRs because they’re grossly uncompetitive; and IFRs with their fuel cycle would cost even more and probably be less reliable.

It’s feasible today to ‘burn’ plutonium in LWRs, but this isn’t done much because it’s very costly, makes each kg of spent fuel 7x hotter, enhances risks, and makes certain transuranic isotopes that complicate operation. IFRs could do the same thing with similar or greater problems, offering no advantage over LWRs in proliferation resistance, cost, or environment.

IFRs’ reprocessing plant, lately rebranded a ‘recycling center’, would be built at or near the reactors, coupling them so neither works without the other. Its novel technology, replacing solvents and aqueous chemistry with high-temperature pyrometallurgy and electrorefining, would incur different but major challenges, greater technical risks and repair problems, and speculative but probably worse economics.

Argonne National Laboratory, the world’s experts on it, contracted to pyroprocess spent fuel from EBR-II – a small IFR-like test reactor shut down in 1994 – by 2035, at a cost DOE estimated in 2006 at ~50x today’s cost of fresh LWR fuel.

Reprocessing of any kind makes waste management more difficult and complex, increases the volume and diversity of waste streams, increases by several- to many-fold the cost of nuclear fueling, and separates bomb-usable material that can’t be adequately measured or protected.

Mainly for this last reason, all Presidents since Gerald Ford in 1976 (except G.W. Bush in 2006-08) discouraged it. An IFR/pyroprocessing system would give any country immediate access to over a thousand bombs’ worth of plutonium to fuel it, facilities to recover that plutonium, and experts to separate and fabricate it into bomb cores – hardly a path to a safer world.

IFRs might in principle offer some safety advantages over today’s light-water reactors, but create different safety concerns, including the sodium coolant’s chemical reactivity and radioactivity. Over the past half-century, the world’s leading nuclear technologists have built about three dozen sodium-cooled fast reactors, 11 of them Naval.

Of the 22 whose histories are mostly reported, over half had sodium leaks, four suffered fuel damage (including two partial meltdowns), several others had serious accidents, most were prematurely closed, and only six succeeded. Admiral Rickover canceled sodium-cooled propulsion for USS Seawolf in 1956 as “expensive to build, complex to operate, susceptible to prolonged shutdown as a result of even minor malfunctions, and difficult and time-consuming to repair.”

Little has changed. As Dr. Tom Cochran of NRDC notes, fast reactor programs were tried in the US, UK, France, Germany, Italy, Japan, the USSR, and the US and Soviet Navies. All failed. After a half-century and tens of billions of dollars, the world has one operational commercial-sized fast reactor (Russia’s BN600) out of 438 commercial power reactors, and it’s not fueled with plutonium.

IFRs are often claimed to “burn up nuclear waste” and make its “time of concern … less than 500 years” rather than 10,000-100,000 years or more. That’s wrong: most of the radioactivity comes from fission products, including very long lived isotopes like iodine-129 and technicium-99, and their mix is broadly similar in any nuclear fuel cycle.

IFRs’ wastes may contain less transuranics, but at prohibitive cost and with worse occupational exposures, routine releases, accident and terrorism risks, proliferation, and disposal needs for intermediate- and low-level wastes. It’s simply a dishonest fantasy to claim, as a Wall Street Journal op-ed just did [7], that such hypothetical and uneconomic ways to recover energy or other value from spent LWR fuel mean “There is no such thing as nuclear waste”. Of course, the nuclear industry wishes this were true.

No new kind of reactor is likely to be much, if at all, cheaper than today’s LWRs, which remain grossly uncompetitive and are getting more so despite five decades of maturation. ‘New reactors’ are precisely the ‘paper reactors’ Admiral Rickover (mastermind of the US Navy’s development of the Pressurized Water Reactor, the PWR) described in 1953:…….

Every new type of reactor in history has been costlier, slower, and harder than projected. IFRs’ low pressure, different safety profile, high temperature, and potentially higher thermal efficiency (if its helium turbines didn’t misbehave as they have in all previous reactor projects) come with countervailing disadvantages and costs that advocates assume away, contrary to all experience.

Thorium reactors Some enthusiasts prefer fueling reactors with thorium – an element 3x as abundant as uranium but even more uneconomic to use. India has for decades failed to commercialize breeder reactors to exploit its thorium deposits.

But thorium can’t fuel a reactor by itself: rather, a uranium- or plutonium-fueled reactor can convert thorium-232 into fissionable (and plutonium-like, highly bomb-usable) uranium-233. Thorium’s proliferation [8], waste, safety, and cost problems differ only in detail from uranium’s: e.g., thorium ore makes less mill waste, but highly radioactive U-232 makes fabricating or reprocessing U-233 fuel hard and costly.

And with uranium-based nuclear power continuing its decades-long economic collapse, it’s awfully late to be thinking of developing a whole new fuel cycle whose problems differ only in detail from current versions.

Spent LWR fuel ‘burned’ in IFRs, it’s claimed, could meet all humanity’s energy needs for centuries. But renewables and efficiency can do that forever at far lower cost, with no proliferation, nuclear wastes, or major risks [9].

Moreover, any new type of reactor would probably cost even more than today’s models: even if the nuclear part of a new plant were free, the rest – two-thirds of its capital cost – would still be grossly uncompetitive with any efficiency and most renewables, sending out a kilowatt-hour for ~9-13¢/kWh instead of new LWRs’ ~12-18+¢.

In contrast, the average US windfarm completed in 2007 sold its power (net of a 1¢/kWh subsidy that’s a small fraction of nuclear subsidies) for 4.5¢/kWh. Add ~0.4¢ to make it dispatchable whether the wind is blowing or not and you get under a nickel delivered to the grid.

Most other renewables also beat new thermal power plants too, cogeneration is often comparable or cheaper, and efficiency is cheaper than just running any nuclear- or fossil-fueled plant. Obviously these options would also easily beat proposed fusion reactors that are sometimes claimed to be comparable to today’s fission reactors in size and cost.

And unlike any kind of hypothetical fusion or new fission reactor – or LWRs, which have a market share below 2% – efficiency and micropower now provide at least half the world’s new electrical services, adding tens of times more capacity each year than nuclear power does.

It’s a far bigger gamble to assume that the nuclear market loser will become a winner than that these winners will turn to losers…..http://www.theecologist.org/essays/2987536/new_nuclear_reactors_same_old_story.html